DPF Removal From
£120 ( Software only )
Most modern diesel cars have
a system called a DPF or diesel particulate system on them to reduce the soot from the exhaust. Unfortunately when
these start to have problems they can be very expensive and problematic.
This can lead to the vehicle going into
'Limp home mode' where the vehicle will run on reduced revs and power etc. until it can be repaired. This can happen
for a number of reasons i.e A fault in the system, Type of use the vehicle gets, Whether or not the system is overdue
for it's DPF service.
We can remove this system from your vehicle
in most cases. The Particulate filter will be removed and the engines ecu program will be altered to NOT having a dpf system
active any more ( This process can be reversed completely but you would need to fit a DPF back on ) We
can carry out the entire removal process for you or only the software part of it should you already have had it removed or
will be removing it.
results of the removal will free you from expensive DPF system services and repairs when it goes wrong, along with better
fuel economy and slightly more power due to the restriction in the
exhaust now being removed.
While we are altering the ecu map you can
also opt for an Eco, Performance & Eco or a Power Map upgrade at the same time and save money on the upgrade.
Please dont leave it till the DPF system
has a permanent fault as this may need to be rectified first before we do the work to ensure you do not have any further
Please also bear in mind that removal should
only really be carried out if the system can not be rectified permanently and if you decide to have the system cleaned
( DPF systems have a cleaning function that is called Regeneration which should work ) Then there is either a problem with
the system that is causing it to block up or the type of driving the vehicle gets does not meet the systems Regeneration function
parameters for carrying out the cleaning of the filter. So you could be spending a couple of hundred £££'s every
few months !
Please Contact Us to discuss the removal or any other
queries you may have.
are now fitted with units called EGR valves that allow an amount of exhaust gases to re-enter the engine to be re-burnt
to lower emissions and hydro carbons. Unfortunately over time these units, especially with diesel engined vehicles start to
get blocked and clogged up, causing no end of running problems and breakdowns etc etc.
can be replaced but will more than likely end up in the same condition again. The cost of some of these EGR units and their
replacement can run into the hundreds of £££'s again.
The EGR valve
can be deactivated in the ecu software and left in the closed position ( so long as it can close ) and this will also have
added benefits of :
So if this EGR valve starts giving you problems Call us before it lets you down.
- Sharper throttle response
- Improved fuel economy
breakdowns due to sticking / defective Egr valves
you have a Motor Home that either feels a little under powered due to extra weight it's carrying or you would like to get
a bit more MPG out of it on long trips etc. Well look no further ! We can carry out a remap to your pride and joy to get you
that little extra power that makes all the difference. Contact us to
book your remap now.